Deluxe Combo

1939 Ford Four Door Deluxe Project Part 2

What do we need to do to get this motor in?

Now its easy to assume that the Ford engine mounts do not match up to the Chevys. We found our Hot Rods engine and trans mounts  at Chasssis Engineering. They come with hardware and simple instructions. Our Ford frame is "X" shaped and has a bracket that strengthens the "X" where the frame intersects. The original needed to be drilled out and refitted with the conversion piece.

Get it together

Our conversion pieces lined up well with the original holes. We needed to enlarge some holes to install bolts, and drill some new holes,  but all in all, its not too bad, just a bit tougher with the body on the car. The lower suspension arms need to be mounted to our center support differently and retrofit brackets are available to do this. The engine mounts are installed via a diagram. Measure twice and drill once. This is very easily done.

Mock it up

We had access to a junk engine and trans for fit. If this is not available to you, do not worry. Just use what you have and be a bit more careful. Our motor and trans fit perfectly with no surprises and looks great. Check all clearances, especially firewall. Chevys have the distributor at the rear so make sure there are no firewall clearance issues. Exhaust clearances are great and steering column will not be in the way of anything.

How does it look?

Our Chevy engine/trans combo weigh about the same as the flathead, so ride height is pretty much the same. The drivetrain dimensions are very similar, but remember that the radiator configuration is different with a Chevy. There should be no height issues as the Ford's hood is very stout and tall.

Final preparation

Once mock engine and trans are removed, we took the time to sand down the brush painted engine compartment. We did some minor bodywork around welded holes and small dents. Again, it all depends on what you want your finished product to look like. Use a good wax and grease remover for a final wipe down. We chose to put a coat of primer prior to applying two coats of a satin black finish. This will allow the focus to be on the engine, and also keeps with the factory look.

Engine and trans paint

Since we are painting, now is the perfect time to paint your engine and trans. Again, we chose the factory lead sled look and painted the engine a dark green while leaving the trans a satin black as well. Our motor was brand new so we took the time to clean and prep prior to painting. Same with the trans. If you do not have a paint booth, allow a good day or two for the paint to dry sufficiently. Dont rush this part as it will just ruin the final product you worked so hard to achieve.

Next time: we assemble the engine and trans and in it goes!

Come visit us at http://www.ratrodauthority.com.com for ideas, parts, vehicles and anything to do with Rat Rods, Muscle Cars, and Hot Rods.

About the Author

Started by Art Tupaczewski, his experience in the auto body industry lead him to devise a way to find
that "specialty part" for your car quickly, easily, and cost effectively. Whether just starting
out, or a seasoned veteran, http://www.ratrodauthority.com has what you need.

After analyzing the marketplace, Art figured out an efficient way to get what you need fast and correct
from the comfort of your own home. His website is the most user friendly and is designed to tell you exactly
what you need to know so you can get back to your project. No guesswork and up to the date
products allow you to move at a rapid rate and checkout quickly.

Whether its an exhaust for your lead sled, wheels for your jalopy, or tires for your Chevelle or Camaro,
you can rest assured knowing that you found the only place to shop for your car.

So always remember, from rust buckets to hot rods, the rat rod authority is available 24 hours a day, 7

Used Fender Deluxe Vm Combo $599.99 In Store Used USED FENDER DELUXE VM COMBO

Odyssey CXL116W Deluxe Combo Case with Wheels $349.99 Odyssey CXL116W Deluxe Combo Case with Wheels

Fender 57 Deluxe 12W 1x12 Combo Amp $1999.99 Fender 57 Deluxe 12W 1x12 Combo Amp

Fender 57 Deluxe 12W 1X12 Combo Amp $1999.99 Fender 57 Deluxe 12W 1x12 Combo Amp

Odyssey Cxl116w Deluxe Combo Case With Wheels $349.99 Odyssey CXL116W Deluxe Combo Case with Wheels

Used Fender Hot Rod Deluxe 1X12 Combo $479.99 In Store Used USED FENDER HOT ROD DELUXE 1X12 COMBO

Used Fender Deluxe 900 Combo Amp $199.99 In Store Used USED FENDER DELUXE 900 COMBO AMP

DEWALT DG5640 16-Pocket Deluxe Carpenter's Combo Tool Belt $59.99 16-Pocket Deluxe Carpenter's Combo Tool Belt - DG5640

ICC / TOOL STRIPPER UTP-COAX COMBO DELUXE / ICACSTSUCD $25.62 ICC - TOOL STRIPPER UTP-COAX COMBO DELUXE - ICACSTSUCD

Fender Blues Deluxe Reissue 40W 1x12 Combo Amp $769.99 Fender Blues Deluxe Reissue 40W 1x12" Combo Amp

Fender Vintage Reissue '65 Deluxe Reverb Guitar Combo Amp Black $869.99 Fender Vintage Reissue '65 Deluxe Reverb Guitar Combo Amp Black

Altieri Oboe / English Horn Bag Deluxe English Horn / Combo Bag $129.95 Altieri Oboe / English Horn Bag Deluxe English Horn / Combo Bag

Used Fender Cyber Deluxe Combo W/Ftsw 050512 $349.99 In Store Used USED FENDER CYBER DELUXE COMBO W/FTSW 050512

Used Fender Blues Deluxe Reissue 40W Combo Amp $549.99 In Store Used USED FENDER BLUES DELUXE REISSUE 40W COMBO AMP

Used Fender Hot Rod Deluxe 1X12 Combo 052012 $449.99 In Store Used USED FENDER HOT ROD DELUXE 1X12 COMBO 052012

Used Fender Hot Rod Deluxe 1X12 40W Combo $424.99 In Store Used USED FENDER HOT ROD DELUXE 1X12 40W COMBO

Used Fender Deluxe 90 Dsp 1X12 Combo 042212 $199.99 In Store Used USED FENDER DELUXE 90 DSP 1X12 COMBO 042212

Used Fender Deluxe 900 Combo Amp 1X12 @782 $199.99 In Store Used USED FENDER DELUXE 900 COMBO AMP 1X12 @782

Fender Blues Deluxe Reissue 40W 1X12 Combo Amp $769.99 Fender Blues Deluxe Reissue 40W 1x12" Combo Amp

Fender Deluxe Vm 40W 1X12 Tube Guitar Combo Amp Blonde $799.99 Fender Deluxe VM 40W 1x12 Tube Guitar Combo Amp Blonde

Hartz Deluxe Nylon Living Combo Brush 83801 $18.94 Deluxe dog comb. Deluxe Nylon combo brush. An essential part of a pet's regular grooming. Keep's your pet looking great. Length: 2. Width: 9.13. Height: 2.5

Hartz Deluxe Nylon Living Combo Brush 83801 $24.35 Deluxe dog comb. Deluxe Nylon combo brush. An essential part of a pet s regular grooming. Keep s your pet looking great. Length: 2. Width: 9.13. Height: 2.5

Used Fender Deluxe Vm Vintage Modified Combo 8.0 845 012612 $549.99 In Store Used USED FENDER DELUXE VM VINTAGE MODIFIED COMBO 8.0 845 012612

Used Fender Deluxe 90 Dsp Guitar Combo 624 42112 $149.99 In Store Used USED FENDER DELUXE 90 DSP GUITAR COMBO 624 42112

Used Fender Cyber Deluxe 1X12 65W Gtr Combo @826 $219.99 In Store Used USED FENDER CYBER DELUXE 1X12 65W GTR COMBO @826

Odyssey CXL104 Deluxe Combo Case $229.99 The Odyssey CXL104 Deluxe DJ rack case has 4 vertical spaces and features a flush mount slanted top section and more sizes. 21"W x 19"H x 20"D. 17" interior depth. 47 lbs.

Odyssey Cxl104 Deluxe Combo Case $229.99 The Odyssey CXL104 Deluxe DJ rack case has 4 vertical spaces and features a flush mount slanted top section and more sizes. 21"W x 19"H x 20"D. 17" interior depth. 47 lbs.

Amazing Journey Deluxe Combo $649.99 "Gospel Light's all-new K.I.D.S. CHURCH imparts life principles that kids can apply immediately with their friends, on the school bus and at home. Kids will navigate their way through God's Word with confidence, see Jesus in every lesson and understand the chronological order of important Bible lessons and characters. Both large and small group segments are included."

Wonderfully Made Deluxe Combo $499.99 "Gospel Light's all-new Jr. K.I.D.S. CHURCH allows you to take your preschoolers on an amazing life journey as they discover that God made them for a specific purpose and plan."

Carrand Deluxe Detail Brush Combo 92004 $24.13 Deluxe detail brush combo. Soft nylon bristles with V pattern cleans hard to reach areas. Tough brass bristles are used to clean rust spots spark plugs and batteries. Stainless steel bristles scratch brush for body rust removal. Brush design allows thumb and finger positions for extra pressure. Ergonomically designed handles. 3 brush combo kit. Carded. Length: 0.75. Width: 9.5. Height: 4

Deluxe Youth Combo Skate and Scooter Protective Pack $40.7 The Deluxe Youth Combo Skate and Scooter Protective Pack includes knee and wrist guards. This protective gear spotlights impact resistant shields, lightweight breathable micro mesh padding and a Velcro strap closure system.Deluxe Youth Combo Protective PackCombo pack includes knee and wrist guardsColors: Black/silver/redImpact resistant shieldsLightweight breathable micro mesh paddingAdjustable Velcro strap closure systemMaterials: Polypropylene/EVA foam/nylonDimensions: 5 inches high x 15.5 inch wide x 13.5 inches longModel: 5145J

This entry was posted on Friday, March 5th, 2010 at 12:24 pm and is filed under Uncategorized. You can follow any responses to this entry through the RSS 2.0 feed. You can leave a response, or trackback from your own site.